How safe is a PCP airgun?

By B.B. Pelletier

How safe is a PCP airgun? That’s a good question, especially if you’re thinking about buying one.

PCPs are the oldest of all airgun designs. Some are more than 400 years old and still in working condition. There are no spring guns that old to compare to. But, let’s talk about the bad side of a PCP.

Has any PCP ever blown up?
I’ve heard rumors of this, but I’ve never seen real facts. I do suspect there have been some accidents because there are a lot of tinkerers in the world, and I have seen some scary stuff. Like the guy who took a brass CO2 airgun (runs on 900 psi CO2) and, without strengthening it in any way, turned it into a 3,000 psi PCP. If that gun blew up would that be a real accident or just stupidity’s reward? But, for an unaltered factory airgun to blow up, a whole lot of unlikely things would have to go wrong.

There are also some safety regulations on our side. The Department of Transportation regulates pressure vessels in the U.S., and they require safety burst disks on any vessel greater than two inches outside diameter. That they do not require them for smaller vessels means they are inherently safe and don’t present a great enough hazard to be concerned.

The one airgun that has a reservoir that qualifies for a burst disk, has itthe AirForce tank. To date, there has NEVER been a report of a burst disk failure in an AirForce air tank. If the tank’s internal pressure were to rise too high, the burst disk is designed to pop harmlessly and release all the air inside. It might shock you if it happened, but there would be no danger of injury.

What about an air reservoir rusting out?
This is another persistent rumor I’ve never actually seen happen. People get hyper-concerned about moisture in the air they use to fill their guns, and these stories get started. But, a 300-year-old PCP that still has its original brazed iron reservoir in good condition is proof enough that a rust-out catastrophe will probably not happen soon.

How about a petroleum/air explosion?
This is a dangerous possibility when shooters lubricate with the wrong oils, but, once again, I have no evidence that an accident ever happened. Lubricate high-pressure air vessels with pure silicone, only – never with petroleum-based oil or grease.

Two real PCP accidents
The two accidents I know of happened within a few miles of each other. One was an experimenter who was pressure-testing a reservoir he had made. He should have used hydraulic oil, but he didn’t know that and used air, instead. The reservoir distorted as he filled it and finally blew up. He suffered no injuries, thank goodness, and now he does all testing with hydraulic oil. The other incident was a rubber-covered air hose that blew out while I was filling my gun. The hose was aftermarket and NOT up to specs for PCP use. I learned my lesson without harm, and I’m passing it on to you.

3 Responses to “How safe is a PCP airgun?”

  • Denny Says:

    Thanks for the info on PCP guns. One more question. Do they work in cold weather? I found out that you can’t hunt rabbits with a co2 gun here in Iowa winters. Sheridans warm you up pumping them up, which is ok. Springers seem to do well in cold weather.

  • B.B. Pelletier Says:

    Denny,

    Quick answer, yes, PCPs do very well in cold weather. In fact, you’ve nominated another posting for next week – Airguns and weather.

    Thanks,

    B.B.

  • Anonymous Says:

    Denny-
    co2 is affected by temperature. it expands when heated and contracts when it is VERY cold. Unless you plan on leaving a tank out in the sun, there should be no problems. And you may get less velocity.

Leave a Reply


+ 7 = 8

Top-notch springer
Air Arms TX200 air rifle

When it comes to spring-piston air rifles, the Air Arms TX200 Mk III is a favorite of many airgunners, including airgun writer Tom Gaylord. His favorite caliber is .177. While the gun will initially impress you with its beauty and superior craftsmanship, you'll be even more impressed with the incredible accuracy! Tom claims this is "the most accurate spring gun below $3,000." Beech or walnut, left-hand or right-hand stock. Isn't it time you got yours?

All the fun, none of the hassles!
Uzi CO2 BB submachine gun

You've seen tons of movies with guys spraying bullets from their Uzi submachine guns and probably thought it would be a blast. Except for the cost of ammo! You can have all that fun with this Uzi BB submachine gun at just pennies a round. Throw shots downrange for hours on end with all the fun, none of the firearm hassles and a fraction of the cost.

Archives